Help & FAQs    Search BCF    Members    Groups    Events Calendar
Resend my activation email : Register : Log in 
BCF: Bike Chat Forums


Hyosung not starting

 Reply to topic
Bike Chat Forums Index -> The Workshop
View previous topic : View next topic  
Author Message

Gawain
Nitrous Nuisance



Joined: 06 Dec 2008
Karma :
PostPosted: 11:23 - 11 Sep 2009    Post subject: Hyosung not starting Reply with quote
My old mans 2005 Hyo 650. Battery been marginal for a while, died properly a week ago - tried bump starting but no joy. Got it going via a jump start from a car, engine off, started no problem. Bought new maintenance free battery and fully charged it, 13.2v after standing, but the bike wont start. Dash lights up as normal but when the starter is engaged it sounds like its trying to turn but the engine wont turn ie sounds like it hits compression then stops and wont go any further. Starter gets warm and battery voltage is depressed after trying to start, 12.7v and when 'cranking'. Cant do a load test as there isnt a light switch.

Prime suspects? Im guessing starter gear or the starter itself. Any tests/suggestions/experience?
Thanks!
 Back to top
View user's profile Send private message You must be logged in to rate posts

P.addy
Red Rocket



Joined: 14 Feb 2008
Karma :
PostPosted: 13:35 - 11 Sep 2009    Post subject: Reply with quote
sounds stupid but my GT used to "not start" like that.
What model is it?
If you put in 2nd, roll it backwards till it locks up, then try starting it.. i know mine used to be a bastard, but when i did that it worked..1/2 the time anyway.
Try new spark plugs?
 Back to top
View user's profile Send private message Send e-mail You must be logged in to rate posts

Gawain
Nitrous Nuisance



Joined: 06 Dec 2008
Karma :
PostPosted: 14:16 - 11 Sep 2009    Post subject: Reply with quote
Double post

Last edited by Gawain on 14:18 - 11 Sep 2009; edited 1 time in total
 Back to top
View user's profile Send private message You must be logged in to rate posts

Gawain
Nitrous Nuisance



Joined: 06 Dec 2008
Karma :
PostPosted: 14:17 - 11 Sep 2009    Post subject: Reply with quote
Thank you! Worked perfectly. Its the GT model. Is this an issue with these bikes? Had only heard of a weak clutch.
 Back to top
View user's profile Send private message You must be logged in to rate posts

P.addy
Red Rocket



Joined: 14 Feb 2008
Karma :
PostPosted: 19:24 - 11 Sep 2009    Post subject: Reply with quote
its not an issue as such.. i just found it a bitch to start so tried that..seemed to work alot Smile
Problems with the bike are the older ones, swing arm fails.. bit of a bugger, and the lower cc models have cam chain tensioner issues.

As far as im aware, there aren't many problems IF you keep on top of maintenance!
 Back to top
View user's profile Send private message Send e-mail You must be logged in to rate posts

Dragonfly
Super Spammer



Joined: 05 Sep 2005
Karma :
PostPosted: 19:46 - 11 Sep 2009    Post subject: Reply with quote
This past week mines been doing that., I have a GT also. Confused Lights on, everything else dead. starts eventually, but I dont know whats causing mine yet. Mines an 07. Also prob with false neutrals Confused Says I am in neutral when I am not its still in first!
____________________
All the breast.
Muzza on Binge:
He's too busy beating the everloving shit out of Lizzie to notice this thread has taken a turn down Drama Avenue and stopped off at the popcorn shop.
 Back to top
View user's profile Send private message You must be logged in to rate posts

P.addy
Red Rocket



Joined: 14 Feb 2008
Karma :
PostPosted: 19:58 - 11 Sep 2009    Post subject: Reply with quote
what CC is that? my 125 always had false neutrals, revving a bit and knocking down from 2nd worked to get it in N.
 Back to top
View user's profile Send private message Send e-mail You must be logged in to rate posts

Dragonfly
Super Spammer



Joined: 05 Sep 2005
Karma :
PostPosted: 20:03 - 11 Sep 2009    Post subject: Reply with quote
padwaxk88 wrote:
what CC is that? my 125 always had false neutrals, revving a bit and knocking down from 2nd worked to get it in N.


125 also. When I go to get on it I used to start and then jump on, till false neutrals took over and my bike was once on the ground as it jumped forward. Knocked me over to Embarassed Confused had to buy a near gear lever for that one. Happened a few times after only lucky I sit on it and hold the breaks now. Its just stopped not started earlier. This is when engine is in use . Went to get stuff earlier on it and ended up sitting there like a twat hitting start and nothing happening. I kicked up and down ths stand and it did then so it maybe connected there.
____________________
All the breast.
Muzza on Binge:
He's too busy beating the everloving shit out of Lizzie to notice this thread has taken a turn down Drama Avenue and stopped off at the popcorn shop.
 Back to top
View user's profile Send private message You must be logged in to rate posts

P.addy
Red Rocket



Joined: 14 Feb 2008
Karma :
PostPosted: 20:59 - 11 Sep 2009    Post subject: Reply with quote
well mate, i always start clutch in..no matter what, my old bike had the idea of thinking clutch is in and jerking forward when i hit start.. even AFTER the shop looked at it Sad

Problems with the 125s..
Cam Chain Tensioners...get erm sorted big time...

Also if possibly, up your chain and sprocket set to the 250cc ones, 520 pitch chain.. lasts alot longer, doesnt wreck as quick mate.

Apart from that, 125 GT are very very nice Very Happy any mods?
 Back to top
View user's profile Send private message Send e-mail You must be logged in to rate posts

Dragonfly
Super Spammer



Joined: 05 Sep 2005
Karma :
PostPosted: 22:34 - 11 Sep 2009    Post subject: Reply with quote
I will get it sorted I hate being stranded and panicing,. has blue flame exhaust . I havnt really done anything to it apart from a hyosung top yoke cover (which looks perfect for the bike).
piccy.
https://i120.photobucket.com/albums/o177/CRMCC/dragonfly/th_IMG_3602.jpg
____________________
All the breast.
Muzza on Binge:
He's too busy beating the everloving shit out of Lizzie to notice this thread has taken a turn down Drama Avenue and stopped off at the popcorn shop.
 Back to top
View user's profile Send private message You must be logged in to rate posts
Old Thread Alert!

The last post was made 17 years, 28 days ago. Instead of replying here, would creating a new thread be more useful?
  Display posts from previous:   
This page may contain affiliate links, which means we may earn a small commission if a visitor clicks through and makes a purchase. By clicking on an affiliate link, you accept that third-party cookies will be set.

Post new topic   Reply to topic    Bike Chat Forums Index -> The Workshop All times are GMT + 1 Hour
Page 1 of 1

 
 You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum
You cannot attach files in this forum
You cannot download files in this forum

Read the Terms of Use! - Powered by phpBB © phpBB Group
 
Debug Mode: ON - Server: birks (www) - Page Generation Time: 0.23 Sec - Server Load: 1.01 - MySQL Queries: 17 - Page Size: 67.22 Kb